Tips for First Time Big Green Egg Users

I've had several members of my family and friends getting a BGE lately.  This made me want to put together a checklist of starter information so I can point them to this post instead of me having to teach them how to use it.  I'm just joking...kind of.

Firstly, from purely a Big Green Egg 101 standpoint, here's how you get started (here are some videos from Big Green Egg).  Insert the firebox and make sure the bottom charcoal grate is in place to keep the coals off the bottom and allow oxygen flow.  Then the fire ring and finally the grate.  Close the dome and install your felt lining around the chimney and put on either the black, cast iron adjustable chimney cap or your green ceramic cap if you will not be using it immediately.

From a first time operations standpoint, remove the top chimney cap, open the dome and open the bottom vent all the way.  Also, remove the food grate.  This is the setup you will always use to light your Egg because it is getting the fullest supply of oxygen with this configuration.  Pile in some charcoal into the firebox and light your coals with the method of your choice.  As the coals start to light and spread, you can replace the grate and close the dome.  If you do it too soon, you'll limit the oxygen getting to your fire and it may go out or fail to light.  This just takes a few times of trial and error to master, you just want to make sure some of the coals are on fire before closing.  With the dome closed, the top damper removed and the bottom vent open, your Egg's temp should start to rise.  It might take a few minutes to move the temperature significantly, but stay near by because if left wide open, it can jump up to 700 degrees rather quickly.  Depending on what temperature you are cooking at, you can now begin to close your vents and damper to a point that will maintain your desired temp.  So if you're going to cook a pork shoulder at 225 degrees, you'll have the bottom vent only open about a quarter of an inch and the top vent just cracked open.  If you're cooking a steak at 600 degrees, you'll have both open much more. Again, this will just take a few attempts to understand how these control the temperature of your Egg.

Here are few things to keep in mind:

1. This is really the only item from a safety standpoint.  When opening the egg, especially at higher temps, you need to always "burp" the Egg.  This is simply opening the Egg slightly (about 1-2 inches).  This allows oxygen to slowly creep in and lets the fire react.  Otherwise, if you quickly rip open the dome, a large influx of oxygen hits a very hot fire and you will have a flare up similar to a back draft.  Most people have to experience this a time or two and burn the hair off their hands before heeding this warning.
2. The first time you use your Egg, they say to season it by doing a short cook at relatively low temps.  I think they just don't want you to jump into cooking at 700 degrees or doing a 24 hour cook right off the bat.  I also think this fully cures the felt lining gasket so that it completely adheres to the Egg lining (which is really the only part of the egg that needs to be periodically replaced).  I just cooked burgers on my inaugural cook at 300 degrees to break in my Egg.
3. Never use lighter fluid.  And I'd go as far to say never use briquettes although I hear you can.  I always use lump hardwood charcoal.  Kind of the whole point of using a BGE is a natural, instinctual way of cooking food.  Don't mess that up by using chemicals like lighter fluids, etc.
4. Never use water in any way.  Not to clean your egg, not to put out coals, never.  Closing the dampers for a few seconds will bring down any out of control flames you have going.  I don't even soak my wood chunks (by the way, never use pellets or chips, stick with the big chunks).  Closing the damper and vents after your done cooking will allow you to reuse much of the charcoal in the fire box.
5. Forget everything you know about using a gas grill or regular charcoal grill.  For instance, to increase or decrease your temperature, don't make big changes to the damper or vent.  I've heard it described this is more like operating a boat than driving a car.  A slight turn will eventually make a boat go a completely different direction.  Same with the Egg, slight adjustments can raise the temperature 25-50 degrees.
6. It's ideal to wait until the smoke goes clear or blue before cooking (see link for example pics).  At first, you'll see a heavy white or gray smoke.  This can make your food taste bitter.
7. If you are going to slow cook at a low temp, make sure you don't let the egg get too hot before attempting to arrive at your target temp.  If you let it get up to 600 degrees, it will be challenging to bring the temp back down to the desired range in the time-frame you probably wanted to put the meat on.
8. It's easy to get information overload when trying to learn how to use the Egg.  You will have to do a lot of experiments to determine what works best for you, your tastes and your favorite types of meats to cook.  The good news is, these experiments are fun and it is really, really hard to screw up food on the Big Green Egg.  Enjoy the learning process and don't stress about it.

Here are some references:

http://www.smoking-meat.com/big-green-egg-instructions